I remember installing some early version residential Energy Recovery Ventilators (ERV) and discovering a potential freezing issue.  Also, if I used only a Heat Recovery Ventilator (HRV) than I would be drying the air during the Winter, and adding significant latent load in the summer.  So, which one do I choose?  The homes are tight enough these days to require mechanical ventilation, and I would much rather a balanced ventilation system that I can control.

Honeywell HRV

 
  An HRV works well for tight, moisture prone homes.  This is because the unit can actually recover up to 85% of the exhaust air's heat, preheating the incoming fresh air.  A small diagram from Honeywell shows how the air crosses paths on the core to cause this transfer, with as little as 10% contamination.  Unfortunately, any ventilation in New England will reduce the indoor relative humidity in the Winter due to the cold, dry fresh air.  This means that in the Summer, the very humid air can be tempered, but will increase the indoor RH and cause an increase in load on your air-conditioner.  Since our part of the country sees approximately 2,500 run hours in heating, and only 500 in cooling, I would recommend installing an HRV on heating only equipment or tight homes with many occupants or latent load in the Winter.  This means there was no need to install a humidifier!

Honeywell ERV

 
  For those homes with an air-conditioner, or concerns about moisture control (too dry in the winter), than I would always recommend an ERV.  An ERV not only transfers the heat, but controls a small amount of moisture as well.  This will not remove the need for a dehumidifer, but will certainly decrease the load caused by your ventilation efforts.  Those old freeze-up problems I saw on the early systems were addressed years ago with more integrated controls that actually sense defrost.  If the temperature in these units get below 20F in the Winter, the fresh air damper closes to increase the temperature of the core and avoid freezing!  The most important feature of the ERV is the moisture transfer.  For instance, if the hot, humid Summer air was to enter the home or central a/c unchecked, this would increase the latent load of the unit and create a situation where the homeowner may be uncomfortable and turn off their ventilation.  By removing up to 80% of this load, there is little tax on the central a/c.  ERV's are most cost effective in extreme climates like New England.  I would also install an ERV in a climate like Miami, extreme latent loads year round.  Just remeber, it is not the outdoor climate that determines which unit to install, it is the indoor climate of the home and possibly HVAC equipment that decides which system is best!

Cross-posted from the Excess Air Blog.

Views: 1315

Comment

You need to be a member of Home Energy Pros Forum to add comments!

Join Home Energy Pros Forum

Comment by Chris Morin on April 21, 2012 at 9:58pm

Thanks for pointing this out George.  Residential systems are about 90% effective when transferring this moisture and heat from the outgoing air - meaning about 10% "cross-contamination".  I am sure some commercial grade systems out there may certify 0%...

Comment by George W. Reynolds on April 20, 2012 at 9:53am

Do the manufactures of ERV's certify that only moisture (H2O distilled grade) will transfer into the fresh air side and that water soluble toxins and aerosols remain in the exhaust stream?

Forum Discussions

More people than ever think green when buying a home

Started by Diane Chojnowski in General Forum. Last reply by Michael Cuomo 4 hours ago. 2 Replies

Worst boiler ever?

Started by Mark Furst in General Forum. Last reply by Dennis Heidner 15 hours ago. 4 Replies

How to Insulate Exposed Outdoor Ductwork?? Help

Started by Daniel Baur-McGuire in General Forum. Last reply by Ed Fritz 20 hours ago. 9 Replies

REALLY????

Started by Danny Gough in HVAC. Last reply by Danny Gough on Saturday. 12 Replies

Where to spend my marketing dollars?

Started by Trip Smith in Marketing. Last reply by Building Performance Institute May 14. 10 Replies

Easy Tests for HVAC during audit

Started by Craig Bird in Weatherization. Last reply by John White May 9. 19 Replies

Water heater ventilation question

Started by Luis Hernandez in General Forum. Last reply by Dennis Heidner May 8. 23 Replies

Latest Activity

Michael Cuomo replied to Diane Chojnowski's discussion More people than ever think green when buying a home
"I totally agree with all the points as it is true that one can go for a home which reduce their…"
4 hours ago
Future Solar WA posted a blog post

How much does a 1.5kW solar power system cost in Perth?

Mostly the cost of 1.5kW solar power system depends on the region and it’s DNI (a measure of amount…See More
4 hours ago
Edwin Rodriguez-Ubinas posted photos
7 hours ago
Drew Cameron is now a member of Home Energy Pros Forum
8 hours ago
Dennis Heidner replied to Mark Furst's discussion Worst boiler ever?
"Wow,  a combination boiler and basement fireplace... great for toasting marshmellows and…"
15 hours ago
Joe Hughes posted an event

IAQ Radio - Episode 547 - Flashback Friday - Claudette Hanks Reichel, Ed.D at Online Live

May 24, 2019 from 12pm to 1pm
Claudette Hanks Reichel, Ed.DBuilding Science & Housing Resilience: Bringing Research to…See More
17 hours ago
Ed Minch replied to Mark Furst's discussion Worst boiler ever?
"that's right up there"
17 hours ago
Jim Gunshinan posted a blog post
18 hours ago

© 2019   Created by Building Performance Association   Powered by

Badges  |  Report an Issue  |  Terms of Service