How North Dakota Learned to Weatherize Manufactured Homes

How Oil Pointed the Way to Home Energy Savings

 

Don Ames

 

When the oil fields began to be developed in places like North Dakota, manpower was an immediate need. Manpower was needed in remote places where the oil was hiding and having enough ready housing was a problem. The cheapest and quickest solution was manufactured housing. Pull it in, set it up, and your done.

Manufactured home communities began to sprout up over night and the housing shortage was in the process of being met. While crews worked to bring in more oil, nobody seemed to pay much attention to the amount of energy those manufactured homes consumed through a cold winter.

It wasn’t until oil development slowed down a bit and families became concerned about their energy bills that somebody started to look at energy use and what could be done to use less power. With temperatures below zero for weeks and the wind at a near steady 30 miles an hour - along with $400 electric bills, the potential for dramatic energy savings was there if it could be realized.

Research was started that was a combined effort of energy specialist from power companies, the State Department of Energy and the State Universities. During this research period, two identical manufactured homes were placed in a building and subjected to the same temperature and wind conditions. Both homes were fitted with the same data collectors and energy monitoring equipment.

One home was left as it was and the other home was used to experiment with different weatherization measures. As an example, both homes had 3 inches of batt insulation installed at the factory when they were built. Now researchers, with the help of blower door equipment, took the second home and air sealed the ceiling. This air sealing measure reduced the amount of air leakage through the ceiling and roof.

This air sealing measure encouraged the researchers as the data loggers indicated noticeable energy conservation. One by one, additional measures were afforded to the second home and data was recorded as to the effectiveness of each measure.

This North Dakota research is just one of the studies that have been done to determine how homes waste energy and how different weatherization measures effect saving energy. When you finally schedule that energy audit of your home and the auditor tells you that your heating ducts need to be sealed and duct sealing is one of the most cost effective measures you can do to a home to save energy, go ahead and nod your head, after all, they may have gotten their auditor training in North Dakota.

Thanks again for stopping by Detect Energy, come back soon, but I won’t leave the light on for you…

http://detectenergy.com/nuclear-oil-coal-hydro-gas/north-dakota-lea...

Views: 99

Tags: Dakota, North, air, energy, insulation, save, sealing, weatherization

Comment

You need to be a member of Home Energy Pros Forum to add comments!

Join Home Energy Pros Forum

Forum Discussions

Too many Heat Pump Water Heaters in a basement?

Started by Brad Cook in General Forum. Last reply by David Butler 18 hours ago. 9 Replies

How would you insulate this roof?

Started by David Butler in General Forum. Last reply by David Butler 19 hours ago. 2 Replies

Dirty solar panels

Started by Evan Mills in General Forum. Last reply by Stacie Bagnasco yesterday. 1 Reply

Fixing a water heater?

Started by John Shillito in Best Practices. Last reply by Eric Kjelshus on Friday. 21 Replies

Latest Activity

Profile IconTroy Spindler, Mike Berg, Andrew McDowell and 4 more joined Home Energy Pros Forum
18 minutes ago
David Butler replied to Brad Cook's discussion Too many Heat Pump Water Heaters in a basement?
"theoretically, let's say you perfectly isolate the HPWH from a heat source. The HPWH's…"
18 hours ago
David Butler replied to David Butler's discussion How would you insulate this roof?
"Interesting idea. Commercial roof on a slope! Typical density for roofing spray foam is 2.5 to 3.0…"
19 hours ago
Summer Redman added a discussion to the group Job Board
Thumbnail

Hiring 2 Training Specialists in Champaign-Urbana, Illinois

The Applied Research Institute (ARI) at the University of Illinois at Urbana-Champaign is seeking…See More
20 hours ago
Summer Redman joined Diane Chojnowski's group
Thumbnail

Job Board

This group is for posting jobs related to all aspects of the home performance industry including…See More
20 hours ago
Profile IconCrystal McLain, Robert Grindrod, Rich Wickman and 3 more joined Home Energy Pros Forum
yesterday
Stacie Bagnasco replied to Evan Mills's discussion Dirty solar panels
"This is a great idea. I clicked on your discussion because it made me remember that I forgot to get…"
yesterday
Kirsten Richnavsky posted an event
Thumbnail

rCloud - The Future of Testing at Your Office or Home

October 18, 2017 from 2pm to 3pm
Integrating rCloud as an essential part of your RESNET QA process.Retrotec’s rCloud app is here,…See More
yesterday

Photos

Loading…
  • Add Photos
  • View All

© 2017   Created by Home Performance Coalition (HPC)   Powered by

Badges  |  Report an Issue  |  Terms of Service