Looking for a cure for a warping hardwood floor not caused by a leak

I have a client who is has a lovely house built in 2010 that has oak hardwood floors throughout. There are apparently no other moisture issues besides the hardwood flooring. This problem is on the third floor and the house has hardwood on all three floors. The owner is noticing that the first floor is starting to have the same problem. Important to note that the third floor warping is directly in the middle of the floor and runs the length of the third floor. The house has an open staircase that goes from the first to the third floor. There has not been any moisture around the windows. The house has warm air heating. The floor(s) have been replaced but they are warping again. Owner is assuming that it is an excessive moisture problem and wants to install dehumidifiers.
I haven't seen the house yet and a blower door test has not been done. I don't want him to spend money on an expensive dehumidification system if it isn't going to cure the problem. Thoughts would be welcome.

Tags: humidity, warped floor

Views: 20448

Reply to This

Replies to This Discussion

David,  your suggestion is really very good.  Since so many dishwashers are hooked up into the sink,  it's obvious to check only the sink.  But if the dishwasher motor seals are failing,  water will drip out onto the flooring and follow it back to the lowest point.  Seldom is the lowest point in a floor near the outside walls.  And it may be following the subfloor  -- mostly invisible to the owners.

Nine years in the house is about the time you would expect dishwasher seals to fail..

Refrigerator leaks can do the same...

How are your gutters and downspouts and extensions functioning? and is the land still banked away from the house properly?  Hundreds of gallons of water come off an average size roof during a say 1" rainfall. Best time to look at this is during a downpour.  I had one home that went from needing 2 basement dehumidifiers emptied each day to once every 2 days just by regrading a few spots around the perimeter of the house.

I'm skeptical there is a humidity problem on an upper floor this time of year, but first step would be to gather data. Measure humidity. For $100 or less one can by a USB ported temperature and humidity logger.

Does the home have excessive internal sources of humidity such as 5 big dogs or a gazillion house plants?

This may be too easy of an answer, but I had a problem similar to this in a rental home I was working on. Turns out the occupant was using a steam mop (Shark) and thought nothing of it since she "used it on all her hard floors." This is probably something that is laughably simple compared to what you are facing, but you might want to gingerly ask how the floors are generally cleaned at your clients home.

My observation is this - Mid Atlantic region:  If a 2400 ft2 house is at about 5-8 ACH50 (which most new houses here have been at since about 2000) and there are 3-4 people in it, then the RH is about 40-45% if there are no other moisture problems.  Enough spaghetti gets cooked, enough showers get taken, and enough breathing is going on to supply a balance with the air leakage to maintain a reasonable RH. If the house gets smaller, tighter, or more heavily occupied, you can get problems.  Likewise if a house is bigger, looser, or more lightly occupied you can get problems.

One of the local large (3-400 a year) national builders specializes in houses over about 3500 ft2 and on up to about 6500 ft.  They found that if they installed a humidifier on each system as standard (either 2 or 3 systems) their floor warranty problems virtually disappeared.

If this house has 3 living floors, it may be a large house.  And the third floor maybe the warmest, therefore have the lowest RH.

RSS

Latest Activity

Bob Krell joined Tom White's group
Thumbnail

Trainers and Mentors

Share your experience with different training and mentoring methods. Learn about new training…See More
6 hours ago
Bob Krell replied to Bob Krell's discussion What Do You Do When You Find Suspected Mold? in the group Healthy Indoors (IAQ)
"Most of the moisture issues there can be attributed to failure to get the roof system completely…"
7 hours ago
Bob Krell replied to Bob Krell's discussion What Do You Do When You Find Suspected Mold? in the group Healthy Indoors (IAQ)
"You are correct about it being multi-family.  It is, in fact, an assisted-living facility, so…"
7 hours ago
Quinn Korzeniecki added a discussion to the group Building Performance Institute (BPI)
Thumbnail

Weatherization Pros: Only 9 Days Left to Apply for Free BPI Certification Exams!

Are you a weatherization professional? Don't miss your chance to get the costs of your new 2018 BPI…See More
7 hours ago
Quinn Korzeniecki posted a discussion

Weatherization Pros: Get BPI Certification Exam Costs Covered!

Are you a weatherization professional? Don't miss your chance to get the costs of your new 2018 BPI…See More
7 hours ago
Diane Chojnowski replied to David Butler's discussion Beginners Guide: Managing Subscriptions on Home Energy Pros
"Great guide David! Thanks! We send two weekly emails to keep members in the loop about new blogs,…"
8 hours ago
Summer Reyes's blog post was featured

Equipment We Use: Detecting Water With Infrared Cameras

You know water is somewhere on the property, you can smell the mildew, but can't determine the…See More
yesterday
Profile IconGlenn Hourahan and Joseph Frasier joined Home Energy Pros Forum
yesterday

Photos

  • Add Photos
  • View All

© 2017   Created by Home Performance Coalition (HPC)   Powered by

Badges  |  Report an Issue  |  Terms of Service